公司新聞
粉料水泥撒布車打料注意事項？
來源：http://m.xintangt.com/ 日期：2021-04-08
粉料撒布車租賃不同型號的車輛容積是不一樣的，因此打料的時候要特別注意車輛的容積，以免過于打料造成車廂撐鼓變形，甚至于開裂。
The volume of different types of vehicles rented by powder spreader is not the same. Therefore, special attention should be paid to the volume of vehicles when charging, so as to avoid excessive charging causing deformation and even cracking of the carriage.
水泥撒布車出租在施工過程中，有師傅可能會問，為什么我的車還沒裝到相對應的噸數車廂會變形呢？其實這個道理很簡單，這個和施工所用的物料比重有很大的關系。在一定的容積內，物料比重大了，裝載的物料噸位就多，物料比重小了裝載的物料噸位就少。那么如何更好的去注意呢？以下幾個小常識大家可以借鑒一下。
In the process of construction, a master may ask why my car has not been loaded to the corresponding tonnage, and the car will deform? In fact, the reason is very simple. It has a lot to do with the proportion of materials used in construction. Within a certain volume, if the proportion of materials is large, the tonnage of materials loaded will be more. If the proportion of materials is small, the tonnage of materials loaded will be less. So how to pay more attention? Here are some common sense that you can learn from.
（1）、打料時注意好罐車的打料管方向，盡量保持罐車打料管和撒布車打料口在同一位置，避免彎折。
(1) Pay attention to the direction of the feeding pipe of the tank car, and try to keep the feeding pipe of the tank car and the feeding opening of the spreader at the same position to avoid bending.
（2）、撒布操作系統頁面有材料密度設定，可根據材料密度（出廠設定為110×10kg/m?）設定去改變稱重報警提醒，材料密度設定數值越大，說明物料比重越大，稱重報警數值會越大；材料密度設定數值越小，說明物料比重越輕，稱重報警數值會越小。
(2) There is material density setting on the spreading operation system page. The weighing alarm can be changed according to the material density setting (factory setting is 110 × 10kg / M?). The larger the material density setting value is, the larger the material proportion will be, and the larger the weighing alarm value will be. The smaller the material density setting value is, the lighter the material proportion will be, and the smaller the weighing alarm value will be.
（3）、同樣的罐車不同的物料也有裝的多與少的情況，有些罐車師傅也會知道材料密度是多少。比如，同樣的運輸罐車平時裝料35噸就滿了，當天裝了30噸，這種情況就說明該物料比重偏輕，打料施工的時候就必須得特別留意。
(3) For the same tanker, different materials are loaded more or less. Some tanker masters will know the density of materials. For example, the same transport tanker is usually filled with 35 tons of material, and it is loaded with 30 tons on the same day. This situation indicates that the proportion of the material is light, so special attention must be paid to the construction of the material.
（4）、水泥的比重多受原材料比重影響較大；白灰的比重多受干濕度、摻雜的石粉、顆粒料的含量影響較大，白灰施工的時候要特別留意車輛的打料量。
(4) The proportion of cement is mainly affected by the proportion of raw materials; the proportion of lime is mainly affected by the dry humidity, the content of doped stone powder and granular material. Special attention should be paid to the amount of material used by vehicles during lime construction.
（5）、有時可能存在罐車拉來的物料兩車多才能裝下的情況，有的師傅怕麻煩會選擇兩車打完，長時間如此也會對車輛及除塵系統造成損傷。
(5) Sometimes, there may be a situation where more than two trucks of materials can be loaded from the tanker. Some masters will choose two trucks for fear of trouble, which will cause damage to the vehicle and dust removal system for a long time.
粉料撒布車小貼士：
Powder spreader tips:
智能化控制系統：采用德國博世力士樂控制器為核心運算單元、程序化自動控制技術，操作人員只需要輸入撒鋪的重量與寬度，系統會自動計算相關參數進行撒鋪工作。
Intelligent control system: using Germany Bosch Rexroth controller as the core operation unit and programmed automatic control technology, the operator only needs to input the weight and width of spreading, and the system will automatically calculate the relevant parameters for spreading.
獨立的稱重系統：收料計重，上料時可顯示即時料位，料滿自動報警。
Independent weighing system: receiving and weighing, real-time material level can be displayed when loading, and automatic alarm when the material is full.
上料方式：撒布車租賃與散裝粉料運輸罐車直接連接上料，增強了本車的連續作業能力。
Feeding mode: the spreader car rental is directly connected with the bulk powder transport tank car for feeding, which enhances the continuous operation capacity of the car.
簡單易學：操作系統簡單易學，只需要一名駕駛員5分鐘可掌握。
Easy to learn: the operating system is simple and easy to learn. It only takes a driver 5 minutes to master.
感謝您的閱讀，希望以上內容對您有所幫助，如您想了解更多精彩內容請點擊我們的官網：水泥撒布車出租http://m.xintangt.com。
Thank you for reading, hope the above content is helpful to you, if you want to know more wonderful content, please click our official website: Cement spreader taxi http://m.xintangt.com .
公司地址：濟南市槐蔭區經一路273號群盛華城2號樓1-404
公司名稱：山東途暢路橋工程有限公司 
備案號：